Product ID:CLEAR ALKYD FINISHES, 187-00
MSDS Date:08/01/1994
FSC:8010
NIIN:00N064841
MSDS Number: BZKSF

ASPEN PAINTS

1128 SW SPOKANE ST
SEATTLE, WA 98134
US

Emergency Phone: 800-424-9300(CHEMTREC)

Info Phone: 206-682-4603

Preparer: D KIER

Cage: 0ALO9

ASPEN PAINTS/ASAMIPEN AMERICA INC

SEATTLE, WA 98134-1187 US

Telephone: 303-573-1014(MED ONLY)

Cage: 0AL09

>8.0 ML/KG

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 100%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM

>5600

CAS: 71-43-2

RTECS: CY1400000

Fraction By Weight: <0.01%

OSHA PEL SEE 1910.1028

ACGIH TLV: 10 PPM; A2

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

483

RTECS: 9999999VO

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:SEE INGREDIENTS
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHAL:EXCESSIVE INHAL OF VAP CAN CAUSE
NASAL & RESP IRRIT, DIZZ, WEAK, FATG, NAUS, HDCH, POSS UNCON & EVEN
ASPHY. SKIN:PRLNGD/RPTD CONT CAN CAUSE DEFAT & DRYING RSLTING IN
IRRIT & DERM. EYE:CAN CAUSE SEV IRRIT, REDNESS, TEARING & BLURRED
VISION. INGEST:CAN CAUSE GI IRRIT, NAUS, VOMIT & DIARR. ASPIR OF
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZS:MATL INTO LUNGS CAN CAUSE CHEM PNEUM
WHICH CAN BE FATAL. INHAL=13700.0 PPM 4 HRS. RPTS HAVE ASSOC RPTD &
PRLNGD OCCUP OVEREXP TO SOLV W/PERM BRAIN & NERV SYS DMG.
INTENTIONAL MISUSE BY DELIB CONC & INHALING CONTENTS MAY BE
HARMFUL/FATAL.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHAL:MOVE AWAY FROM SOUCE OF EXPOS & INTO FRESH AIR.
EYE:HOLD LIDS OPEN & FLUSH W/WATER FOR @ LST 15 MIN. SKIN:WASH
CONTAM SKIN W/MILD SOAP & WATER. INGEST:DO NOT INDUCE VOMIT. OBTAIN
MED ATTN IMMED. NOTE TO MD:MAIN HAZ FOLLOWING ACCIDENTAL INGEST IS
ASPIR OF LIQ INTO LUNGS PRDCING CHEM PNEUM. CARDIAC ARRHYTHMIAS
HAVE BEEN REPORTED WITH SOLVENT EXPOSURE.

Flash Point Method:TCC
Flash Point:112F,44C
Lower Limits:0.8%
Upper Limits:5.0%
Extinguishing Media:DRY CHEMICAL, CO*2, FOAM AND WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. CAUTN-COMBUST LIQ. EXCLUDE AIR. DO NOT USE WATER EXCEPT AS FOG.
USE WATER TO COOL FIRE EXPOSED CNTNRS.
Unusual Fire/Explosion Hazard:AVOID EXCESSIVE HEAT, OPEN FLAMES AND ALL
IGNITION SOURCES. VAPOR FORMS AN EXPLOSIVE MIXTURE WITH AIR BETWEEN
UPPER AND LOWER FLAMMABLE LIMITS.

Spill Release Procedures:ELIM ALL IGNIT SOURCES. VENT AREA. ABSORB
W/ABSORB MATL SUCH AS SAWDUST, SAND/VERMICULITE & PLACE MATL IN
CLSD CNTNR. IF LG SPILL, DIKE AREA TO PVNT MATL FROM ENTERING WATER
SYS/SEWERS. WEAR PROT EQUI P DURING CLEAN UP. NOTIFY APPROP ENVIRON
(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:"COMBUST LIQ". STORE IN COOL, DRY,
WELL-VENT AREA, AWAY FROM HEAT & IGNIT SOURCES. AVOID PRLNGD/RPTD
CONT W/SKIN. AVOID BRTHG VAPS/SPRAY MIST.
Other Precautions:GROUND CNTNRS WHEN POURING & LIM FREE FALL TO MIN
STATIC CHARGE BUILD-UP. EMPTY CNTNRS COULD CNTN PROD RESIDUE &
VAPS, THEREFORE THEY MAY BE HAZ & ALL CAUTNS ON MSDS WOULD APPLY TO
THEM. DO NOT TAKE I NTERNALLY. CLOSE CNTNRS AFTER (SUP DAT)

Respiratory Protection:A NIOSH/MSHA APPROVED CANISTER-TYPE RESPIRATOR
MUST BE WORN TO PREVENT THE INHALATION OF VAPOR OR SPRAY MIST WHEN
TLV PEL IS EXCEEDED.
Ventilation:GEN VENT IS REQ DURING NORMAL USE. LOC VENT MAY BE REQ IN
CERTAIN CASES TO KEEP EXPOS LEVEL BELOW LIMS LISTED IN INGS.
Protective Gloves:CHEM-RESIST NITRILE, NEOPRENE/RUB REQ.
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS .
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER . WEAR PROTECTIVE CLOTHING TO PREVENT SKIN CONTACT.
Work Hygienic Practices:LAUNDER CONTAMINATED CLOTHING PRIOR TO REUSE.
USE GOOD PERSONAL HYGIENE.
Supplemental Safety and Health
SPILL PROC:AGENCY(IES) IF SPILL EXCEEDS 220 LBS. WASTE DISP METH:DISP
PROC MUST COMPLY W/LOCAL, STATE & FED REGS. REFER TO HAZ CAUTN INFO
IN OTHER SECTIONS OF MSDS. OTHER PREC:EACH USE. KEEP AWAY FROM
CHILDREN.

Boiling Pt:B.P. Text:>301F,>149C
Vapor Pres:>7.0 @ 38C
Vapor Density:4.8
Spec Gravity:0.90
Evaporation Rate & Reference:SLOWER THAN N-BUAC
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, WHITE OR VARIOUS COLORED LIQUID, MILD ODOR.
Percent Volatiles by Volume:60

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS AND ACIDS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT, OPEN FLAME AND ALL
IGNITION SOURCES.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE ARE
PRODUCED ON COMBUSTION.

Waste Disposal Methods:IF NOT POSS TO RECLAIM, MATL & CNTNRS SHOULD BE
TREATED AS HAZ WASTE (EPA #/CODE D001) BASED ON CHARACT OF
IGNITABILITY AS DEFINED UNDER FED RCRA REGS (4OCFR261) & DISP OF AT
LICENSED WASTE DISP COMPA NY/INCIN W/APPROVAL OF ENVIRON AUTH. ALL
(SUPDAT)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.